The tilt rotor aircraft holds great promise for improving air travel in the future. It's benefits include vertical take off and landing combined with airspeeds comparable to propeller driven aircraft. However, the noise from a tilt rotor during approach to a landing is potentially a significant barrier to widespread acceptance of these aircraft. This approach noise is primarily caused by Blade Vortex Interactions (BVI), which are created when the blade passes near or through the vortex trailed by preceding blades. The XV-15 Aeroacoustic test will measure the noise from a tilt rotor during descent conditions and demonstrate several possible techniques to reduce the noise.

The XV-15 Aeroacoustic test at NASA Ames Research Center will measure acoustics and performance for a full-scale XV-15 rotor. A single XV-15 rotor will be mounted on the Ames Rotor Test Apparatus (RTA) in the 80- by 120-Foot Wind Tunnel. The test will be conducted in helicopter mode with forward flight speeds up to 100 knots and tip path plane angles up to ± 15 degrees. These operating conditions correspond to a wide range of tilt rotor descent and transition to forward flight cases.

Rotor performance measurements will be made with the RTA rotor balance, while acoustic measurements will be made using an acoustic traverse and four fixed microphones. The acoustic traverse will provide limited directionality measurements on the advancing side of the rotor, where BVI noise is expected to be the highest. Baseline acoustics and performance measurements for the three-bladed rotor will be obtained over the entire test envelope. Acoustic measurements will also be obtained for correlation with the XV-15 aircraft In-flight Rotor Aeroacoustic Program (IRAP) recently conducted by Ames.

Several techniques will be studied in an attempt to reduce the highest measured BVI noise conditions. The first of these techniques will use sub-wings mounted on the blade tips. These subwings are expected to alter the size, strength, and location of the tip vortex, therefore changing the BVI acoustics of the rotor. The subwings are approximately 20% of the blade chord and increase the rotor radius by about 3 percent. Four different subwing configurations will be tested, including square tipped subwings with different angles of incidence.

The ability of active controls to reduce BVI acoustics will also be assessed. The dynamic control system of the RTA will be used to implement open- and closed-loop active control techniques, including individual blade control. Open-loop testing will be conducted using a personal computer based, automated, real-time data acquisition system. This system features combined automated output of open loop control signals and automated data acquisition of the resulting test data.

A final technique to alter the noise of the rotor will be examined. This will involve changing the number of blades from three to four. A four-bladed rotor hub has been fabricated on which the XV-15 blades will be mounted. While the solidity of the rotor will increase, much useful information can be gained by examining the changes in the thrust and RPM with four blades.

Related Publications:

Kitaplioglu, C., McCluer, M. and Acree, C. W., "Comparison of Full-Scale XV-15 Wind Tunnel and In-Flight Blade-Vortex Interaction Noise," Proceedings of the 53rd Annual Forum of the American Helicopter Society, April-May 1997.

Light, J. S., "Results From an XV-15 Rotor Test in the National Full-Scale Aerodynamics Complex," Proceedings of the 53rd Annual Forum of the American Helicopter Society, April-May 1997.

Light, J. S., Kitaplioglu, C., and Acree, C. W., "XV-15 Aeroacoustic Testing at NASA Ames," Proceedings of the Twenty-Third European Rotorcraft Forum, Dresden, Germany, September 1997.

Point of Contact:

Mark Betzina
NASA Ames Research Center
Moffett Field CA 94035-1000

NASA Ames Research Center, Moffett Field CA 94035-1000, (650) 604-5000
URL: http://rotorcraft.arc.nasa.gov/
This Website Maintained By: Randall L. Peterson.
Responsible NASA Official: Dr. William Warmbrodt (Chief)

Privacy Statement
Ames Research Center Homepage
NASA Homepage

Last Modified: Thursday, 27-Dec-2007 14:40:38 PST