[Federal Register: December 30, 1998 (Volume 63, Number 250)]
[Proposed Rules]
[Page 71800-71806]
From the Federal Register Online via GPO Access [wais.access.gpo.gov]
[DOCID:fr30de98-28]
=======================================================================
-----------------------------------------------------------------------
CONSUMER PRODUCT SAFETY COMMISSION
16 CFR Part 1700
Requirements for Child-Resistant Packaging; Household Products
Containing Methacrylic Acid
AGENCY: Consumer Product Safety Commission.
ACTION: Proposed rule.
-----------------------------------------------------------------------
SUMMARY: The Commission is proposing a rule to require child-resistant
(``CR'') packaging for liquid household products containing more than 5
percent or more methacrylic acid (weight-to-volume) in a single
package. The Commission has preliminarily determined that child-
resistant packaging is necessary to protect children under 5 years of
age from serious personal injury and serious
[[Page 71801]]
illness resulting from handling or ingesting a toxic amount of
methacrylic acid. The Commission is specifically concerned about nail
care products containing methacrylic acid, the only household product
the Commission has confirmed to contain methacrylic acid. The
Commission takes this action under the authority of the Poison
Prevention Packaging Act of 1970.
DATES: Comments on the proposal should be submitted no later than March
15, 1999.
ADDRESSES: Comments should be mailed to the Office of the Secretary,
Consumer Product Safety Commission, Washington, D.C. 20207, or
delivered to the Office of the Secretary, Consumer Product Safety
Commission, Room 502, 4330 East-West Highway, Bethesda, Maryland 20814-
4408, telephone (301) 504-0800. Comments may also be filed by
telefacsimile to (301) 504-0127 or by email to cpsc-os@cpsc.gov.
FOR FURTHER INFORMATION CONTACT: Susan Aitken, Ph.D., Division of
Health Sciences, Directorate for Epidemiology and Health Sciences,
Consumer Product Safety Commission, Washington, D.C. 20207; telephone
(301) 504-0477 ext. 1195.
SUPPLEMENTARY INFORMATION:
A. Background
1. Relevant Statutory and Regulatory Provisions
The Poison Prevention Packaging Act of 1970 (``PPPA''), 15 U.S.C.
1471-1476, authorizes the Commission to establish standards for the
``special packaging'' of any household substance if (1) the degree or
nature of the hazard to children in the availability of such substance,
by reason of its packaging, is such that special packaging is required
to protect children from serious personal injury or serious illness
resulting from handling, using, or ingesting such substance and (2) the
special packaging is technically feasible, practicable, and appropriate
for such substance.
Special packaging, also referred to as ``child-resistant'' (``CR'')
packaging, is (1) designed or constructed to be significantly difficult
for children under 5 years of age to open or obtain a toxic or harmful
amount of the substance contained therein within a reasonable time and
(2) not difficult for ``normal adults'' to use properly. 15 U.S.C.
1471(4). Household substances for which the Commission may require CR
packaging include (among other categories) foods, drugs, or cosmetics
that are ``customarily produced or distributed for sale for consumption
or use, or customarily stored, by individuals in or about the
household.'' 15 U.S.C. 1471(2). The Commission has performance
requirements for special packaging. 16 CFR 1700.15, 1700.20.
Section 4(a) of the PPPA, 15 U.S.C. 1473(a), allows the
manufacturer or packer to package a nonprescription product subject to
special packaging standards in one size of non-CR packaging only if the
manufacturer (or packer) also supplies the substance in CR packages of
a popular size, and the non-CR packages bear conspicuous labeling
stating: ``This package for households without young children.'' 15
U.S.C. 1473(a), 16 CFR 1700.5.
2. Methacrylic Acid
Methacrylic acid (``MAA'') is used as a primer for cleaning,
degreasing, dehydrating and etching fingernails before applying
artificial nails. Nail products containing MAA are cosmetics under the
Food Drug and Cosmetic Act (``FDCA''). According to the FDCA,
``cosmetic'' includes ``articles intended to be rubbed, poured,
sprinkled, or sprayed on, introduced into, or otherwise applied to the
human body or any part thereof for cleansing, beautifying, promoting
attractiveness, or altering appearance.'' 15 U.S.C. 321(i). MAA is also
used as a chemical intermediate in making resins, paints, adhesives,
paper, polishes, plasticizers and dental fillings. However, the
Commission does not believe that these products would be affected by
the proposed rule because, in the process of manufacturing these
products, the bulk of MAA becomes polymerized and is no longer in the
form of the monomer MAA.
Nail primers are used to help acrylic overlays adhere to the nail
surface. Not all nail primers contain MAA. Primers that do contain MAA
may have as much as 100 percent MAA, but some may have other
ingredients. Of the primers examined by the staff, those that do
contain MAA have at least 50 percent MAA. Most of the nail primers that
contain MAA are labeled ``For Professional Use Only.'' They are
generally distributed through wholesale distributors directly to nail
salons and to retail beauty supply stores. Some of these retail stores
sell to both professionals and consumers. To obtain samples, CPSC staff
visited several beauty supply retail stores, and purchased four nail
primers containing MAA. They were packaged in small bottles containing
\1/4\ oz. to \1/2\ oz. of primer. All were sold individually packaged,
none were CR and all were labeled ``Professional Use Only'' or ``For
Professional Use Only.'' The staff obtained an additional primer that
was confirmed to contain MAA by mail order purchase. It came in a non-
CR bottle labeled ``For Professional Use Only.''
According to industry sources, there may be as many as 50 nail
primer suppliers. Approximately 90 percent of nail primers marketed to
professionals contain MAA. The Commission is aware of 13 companies that
market or have marketed MAA-containing nail primers.
Based on industry estimates, the CPSC staff estimates annual unit
sales of MAA-containing nail primers at about 1.0 to 1.3 million units
in \1/4\ oz., \1/2\ oz. and larger sizes. The annual retail value of
these units amounts to $4-6.5 million. The wholesale value of these
products is about $2.9 to $4.6 million based on a 40 percent mark-up
typical of the industry.
Spokespersons for the industry could not estimate the number of
consumers using MAA-containing primers at home. It is clear, however,
from the incident data discussed below that these products are used in
the household, and children are obtaining access to them. The ability
of CPSC staff to purchase these primers at retail stores and by mail
also shows that these products are readily available for consumers to
purchase and bring home.
B. Toxicity of Methacrylic Acid
MAA is readily absorbed through mucous membranes of the lungs and
gastrointestinal (``GI'') tract as well as through the skin. It is
rapidly distributed to all major tissues, with the highest
concentrations in the liver and kidneys. It is a corrosive, meaning
that, when it comes into contact with living tissue, it causes
destruction of tissue by chemical action. 15 U.S.C. 1261(i).
MAA's effects are similar to those of other acids. Dermal burns can
destroy the surface of the epithelium and submucosa with damage to
blood vessels and connective tissue. Inhaling acid vapors may produce
nasal irritation, salivation, conjunctival irritation, difficulty
breathing, pleuritic chest pain, and bronchospasm. Ingestion generally
produces mild to severe oral and esophageal burns and GI bleeding,
perforation, edema, necrosis, stenosis (narrowing of the GI passage)
and fistulas (abnormal passages or outpocketings). Other intestinal
injuries may also occur. Areas of stricture may develop about 3 weeks
after ingestion. Eye exposure may cause pain, swelling, corneal
erosions, and blindness.
C. Incident Data
The staff reviewed several sources for information of adverse
health effects
[[Page 71802]]
from nail products containing MAA. These sources are published reports
in the medical literature, the American Association of Poison Control
Centers (``AAPCC''), the FDA Cosmetic Voluntary Registration Program
(``CVRP''), and reports from the injury surveillance databases
maintained by the Commission.
1. Medical Literature
A recent article in the medical literature analyzed data from the
Toxic Exposure Surveillance System (``TESS'') for 1993 through 1995.
The American Association of Poison Control Centers (``AAPCC'') collects
reports of exposures to toxic chemicals (drugs, household products,
poisonous plants, etc.) made to participating poison control centers
within the United States in the TESS data base. The TESS data base
contains 759 reports of exposures to MAA-containing nail products. Most
of the exposures to children less than 6-years-old occurred in the home
and involved either ingestion or both dermal contact and ingestion.
Children less than 6-years-old accounted for 564 exposures. Two-year-
old children were most at risk (approximately 330 exposures).
Approximately 10 percent of young children suffered moderate to major
injuries.1
---------------------------------------------------------------------------
\1\ ``Minor symptoms'' means that the patient exhibited some
minimal signs or symptoms that resolved rapidly. ``Moderate
symptoms'' means the patient exhibited signs or symptoms that were
more pronounced, prolonged, or of a systemic nature which usually
required some form of treatment (symptoms were not life threatening
and there was no residual disability or disfigurement). ``Major
symptoms'' means the patient exhibited some symptoms that were life-
threatening or resulted in disfigurement or residual disability.
---------------------------------------------------------------------------
A second recent article reviewed the hazard of nail care products,
among them nail primers containing MAA, and reported the medical
consequences of ingestion of and/or dermal exposure to primers in two
children less than 5-years-old and one adult. In the first case, a 21-
month-old male accidentally ingested approximately 3-5 ml of a product
containing at least 98 percent MAA. The child began drooling, gagging,
and vomiting. Physicians at the emergency room (``ER'') of a local
hospital observed that the child was in great distress on arrival 30
minutes after ingestion. He required endotracheal intubation to
maintain the airway and upper GI endoscopy. The upper GI tract,
pharynx, and airways showed severe tissue damage. He developed
bilateral pneumonia and respiratory distress with stridor (a harsh,
high-pitched respiratory sound often associated with acute laryngeal
obstruction). He required positive pressure ventilation for 6 days and
parenteral nutrition for 15 days. A regular diet was resumed only after
he was discharged from the hospital 28 days after he was admitted.
Although x-rays of the esophagus and stomach appeared normal one month
after discharge, the child experienced intermittent episodes of choking
and vomiting. One year later, x-rays confirmed a stricture of the
esophagus. Skin burns on the lips, chin, and neck resolved without
permanent scarring.
A 2\1/2\-year-old male spilled approximately 5-7 ml of a product
containing at least 98.5 percent MAA onto his face, right arm, and
chest. He immediately began screaming. The affected areas were
immediately rinsed with water, and he was treated at a nearby hospital
20 minutes later. ER personnel noted patchy erythema of the face,
chest, right arm, and flank. Blisters developed on his chest. Treatment
included rinsing his body and applying silver sulfadiene and aloe to
burn areas. All burn areas healed without scarring.
A 27-year-old female ingested two artificial nail products. The
first contained MAA and methylethyl ketone. The second product
contained ethyl methacrylate (an ester of MAA), proprietary modifiers,
and polymerization accelerators. The woman arrived at the ER 30 minutes
after ingestion with symptoms of lethargy and cyanosis (a bluish color
of the skin). She also exhibited lesions of the pharynx, mucosal injury
in the mouth and pharynx, and ulcerated areas in the upper esophagus.
Areas of persistent ulceration in the esophagus were still present
after 7 days. She was able to eat a normal diet only after 14 days of
hospitalization. These corrosive injuries were due to the MAA as none
of the other ingredients in these products were known to be corrosives.
2. CPSC Databases
CPSC has several databases for poison incidents--the National
Electronic Injury Surveillance System (``NEISS'') (January 1988--
September 30, 1998), the Injury and Potential Injury Incident
(``IPII'') data base (January 1980--September 30, 1998), the In-Depth
Investigations (``INDP'') data base (January 1980--September 30, 1998),
and the Children and Poisonings (``CAP'') data base (1978-1987). The
staff reviewed these databases for incidents involving nail primers.
Between 1988 and September 30, 1998, the staff identified 85 cases
as exposures to nail products specifically identified as primers or as
containing MAA. It is possible that other incidents may have implicated
primers and that some of the primers involved in these incidents did
not contain MAA.
NEISS is a stratified probability sample of ER hospitals in the
United States and its territories. The staff computed both the national
estimates and sampling errors for ER visits by children less than 5
years old due to exposures to nail primers. Approximately 2,723
estimated ER visits due to exposures to nail primers occurred between
January 1988 and September 1998. The lower and upper 95 percent
confidence limits of this estimate were 1,756 and 3,690 respectively.
Hospitalization was necessary in approximately 10 percent of estimated
ER visits (262). The home was the location of exposure in 83 percent of
the estimated ER visits (2,272). Primers accounted for 11 of the total
15 hospitalizations associated with nail products.
The INDP files provide additional details on some of these
incidents. In one incident, a 2-year-old female spilled a bottle of
nail primer containing MAA when she climbed a chair to reach the
container placed on a table. On opening the bottle, the child spilled
about 1\1/2\ to 2 ounces on her thigh. After trying to rub it off with
her hand she then rubbed her face. The child was quickly rinsed off in
a shower and taken to the ER. She was treated and released. The child
suffered first and second degree burns to her right thigh and both
sides of her face from her eyebrows to the bottom of her cheeks.
A 2-year-old male gained access to an artificial nail kit left on a
living room table. The child was about to ingest the bonding agent
(primer), possibly MAA, when he spilled about one and one-half ounces
on his shirt and around his mouth and nose. He began screaming, turned
pale, appeared lethargic, and his eyes were described as glassy. He was
immediately taken to the ER where his burns were treated. He remained
in the hospital under observation for two nights, was transferred to
another hospital for an endoscopy because of difficulty swallowing, and
was released after a total of four nights in the hospital.
A 12-month-old male experienced chemical burns to his hands and
mouth from a fingernail primer. The child removed the cap of the primer
bottle, and about one ounce of the primer spilled on his hand. The
child then rubbed his mouth with his hand and began drooling and
frothing. He was immediately taken to the hospital. His chemical burns
were treated, and he was released the same day.
[[Page 71803]]
3. AAPCC Data
The staff obtained AAPCC data isolating nail products containing
MAA for the years 1996 and 1997. The data include 467 exposures,
including 341 poisonings (ingestion, ingestion/dermal), 11 ocular
exposures, and 115 dermal exposures to children less than 5-years-old.
No deaths were reported. One poisoning with major medical consequences
was reported in 1997. This incident is discussed below. There were 32
poisoning outcomes coded as moderate (10.7 percent) and 137 poisonings
(39.3 percent) coded as having minor outcomes.
The AAPCC also provided additional information on some exposures
reported to, and collected by individual poison control centers. All
these exposures involved MAA-containing nail primers. All incidents
except one occurred in the child's own residence or in someone else's
residence. A summary of the more significant cases from the collection
follows below.
In an incident coded as having a major medical outcome (1997), a 3-
year-old female experienced burns to her lips and cheeks when she
attempted to ingest a nail primer at a beauty salon. She also suffered
an anaphylactic reaction, presumably to the MAA in the primer. She
remained in a pediatric intensive care unit (ICU) for 2 days. On the
third day, she was transferred to a regular bed and her open cheek
blisters had healed sufficiently to allow treatment with antibiotic
ointment. An endoscopy on day 4 revealed no GI burns, and she was
discharged on day 5.
A 1\1/2\-year-old female experienced burns over half her chest
after spilling a bottle of primer on herself. The child required
outpatient treatment at a burn center for the next 3 weeks and remained
in pain for much of that period. According to the parents, her
physician at the Center was considering skin grafts. The burns required
approximately 4 weeks to heal.
A 20-month-old female spilled some primer in the process of
attempting to ingest it. Blisters formed on the skin and most of the
face within 30 minutes and the child was in evident pain. The pain
persisted several days, and the burns did not begin to resolve for
another week. The primary physician originally recommended consultation
with a plastic surgeon; however, the burns eventually healed without
scarring.
4. FDA Database
The FDA's CVRP database contains four reports of injuries from nail
primers. One of these reports indicates that a 2-year-old male was
brought to the ER after a nail primer splashed in his face and caused
burns to the cornea of the eye and the face (1988).
D. Level for Regulation
The Commission is proposing a rule that would require special
packaging for household products containing more than 5 percent
methacrylic acid.
At this time, there is no evidence establishing the lowest
concentration or amount of MAA capable of causing severe personal
injury or illness to young children. The severity of burns to a human
from corrosive chemicals is dependent on duration of exposure, site of
contact, area of contact, volume and concentration of the product, and
the chemical characteristics of the product. These chemical
characteristics include pH, physical nature, viscosity, titratable
acidity or alkalinity, molarity, oxidation-reduction potential, and
complexing affinity for bivalent ions. MAA is a weak organic acid
closely resembling acetic acid; in terms of acidity, acetic acid is
1.3-fold stronger than MAA when concentration is expressed in percent
units. The Commission arrived at a level for regulation based on
mutually supportive evidence derived from a report of concentration-
related skin injury in mice due to MAA, the calculated pH of various
concentrations of MAA, and the effects of acetic acid on humans at
various concentrations.
Human evidence does not associate exposures to commercial vinegar
(4 to 6 percent acetic acid) with skin burns but suggests these
concentrations cause mild skin irritation. The Toxicological Advisory
Board (U.S. CPSC, 1982) similarly concluded that 5 percent acetic acid
is a weak skin irritant. However, doubling the acetic acid
concentration to 10 percent results in classification as a strong skin
irritant. Doubling the acetic acid concentration yet again to 20
percent requires labeling as a poison under Section 3(b) of the FHSA,
16 CFR 1500.129.
Similarly, concentrations of 4.8 percent MAA cause no irritation
(in aqueous solution) or only mild irritation (in acetone solution) to
the skin of mice. Doubling that concentration to 9.6 percent in an
acetone solution results in epithelial necrosis (tissue destruction)
and adverse effects in the dermis of the skin. This degree of injury
constitutes a second degree burn to the skin and can best be
characterized as severe irritation. Doubling the MAA concentration
again to 19.2 percent causes visible destruction to skin epithelium and
injury throughout all layers of the skin, including the dermis and
submucosal musculature. These skin injuries, if not overtly corrosive,
border on corrosive, causing ``visible destruction or irreversible
alterations in the tissue at the site of contact'' as defined under the
FHSA, 16 CFR 1700.3(c)(3).
Increasing degrees of injury can also be predicted to the eyes with
corresponding changes in MAA concentration (4.8, 9.6, and 19.2
percent). In general, acid solutions with a pH of 2.5 or above cause
little damage to the eye (the lower the pH, the stronger the acid). For
example, the Toxicological Advisory Board classified a solution of 3
percent acetic acid, pH 2.53, as a moderate eye irritant. A 4.8 percent
solution of MAA has a pH of 2.46, and probably would also be considered
a moderate eye irritant, causing reversible inflammatory changes in the
eye and its surrounding mucous membranes. Doubling the MAA
concentration to 9.6 percent produces a solution with a pH of 2.3. This
pH has the potential to produce more serious eye injury with
inflammation of the iris and opacity of the cornea. Doubling the MAA
concentration yet again to 19.2 percent results in a solution of 2.15,
well within the range capable of causing corrosive eye injuries.
The use of organic solvents such as acetone or ethyl acetate in MAA
solutions is likely to increase the degree of injury to eyes, mucous
membranes of the GI and respiratory tract, and skin. MAA is soluble in
aqueous solutions only to a limited extent (10% maximum). Any
concentration of MAA exceeding 9 percent would only dissolve in organic
solvents such as acetone that not only cause mild irritation in their
own right but exacerbate the toxic effects of MAA itself.
The actual degree of irritancy or corrosion at 1 to 20 percent
concentrations would probably depend on the volume of acid in contact
with tissues, the surface area and site affected, and duration of the
contact. A concentration of approximately 5 percent MAA does not cause
serious injury to mouse skin. It is not likely to be more than a
moderate irritant to the eyes of humans, or a mild irritant to the skin
of humans. It is equivalent to a 4 percent concentration of acetic acid
(about the same as vinegar), that is not associated with serious
personal injury or illness in young children. However, concentrations
of approximately 10 percent MAA are, at the very least, severe skin
irritants in a mouse model and, judging from calculated pH values, are
capable of serious eye injury. The weight of the evidence indicates
that solutions containing 5 percent MAA
[[Page 71804]]
will not cause serious personal harm or illness in young children.
Because the staff is not aware of data defining the precise point
between 5 and 10 percent at which injury becomes serious, the staff
recommends that child-resistant packaging be required for products
containing more than 5 percent MAA to protect children from potential
serious injury. The Commission solicits comments on this level.
E. Statutory Considerations
1. Hazard to Children
As noted above, the toxicity data concerning ingestion of MAA
demonstrate that MAA can cause serious illness and injury to children.
Moreover, it is available to children in the form of nail primers that
are accessible in the home. These packages are not CR.
Pursuant to section 3(a) of the PPPA, 15 U.S.C. 1472(a), the
Commission preliminarily finds that the degree and nature of the hazard
to children from handling and ingesting household products containing
MAA is such that special packaging is required to protect children from
serious illness. The Commission bases this finding on the toxic nature
of MAA-containing products and their accessibility to children in the
home.
2. Technical Feasibility, Practicability, and Appropriateness
In issuing a standard for special packaging under the PPPA, the
Commission is required to find that the special packaging is
``technically feasible, practicable, and appropriate.'' 15 U.S.C.
1472(a)(2). Technical feasibility may be found when technology exists
or can be readily developed and implemented to produce packaging that
conforms to the standards. Practicability means that special packaging
complying with the standards can utilize modern mass production and
assembly line techniques. Packaging is appropriate when complying
packaging will adequately protect the integrity of the substance and
not interfere with its intended storage or use.
The staff evaluated the packaging of ten nail primer products. Five
of these nail primers contained MAA. Four of the five were packaged in
0.25 to 2 ounce brown or tinted glass bottles with 13-20 millimeter
(``mm'') non-CR continuous threaded (``CT'') plastic closures. One was
in a brown plastic bottle with a non-CR plastic closure. Three of the
five packages included a built-in applicator brush, one had a separate
applicator brush, and one completely lacked an applicator brush. One
primer was packaged in a plastic marker pen with a fiber applicator
tip, preventing any substantial flow or spillage of free liquid from
the device. The staff is aware of a similar device used for an MAA-
containing primer sold through a mail order catalog.
Packaging for MAA-containing nail primers that is senior friendly
(``SF'') and CR is technically feasible. There are currently available
20 mm CT caps without built-in applicator brushes that are SF and CR.
The manufacturer of this cap also manufactures a 28 mm CT closure that
is CR and SF and has a built in applicator brush. This manufacturer has
indicated to staff that it could develop a 20 mm CR and SF cap with a
built-in applicator brush suitable for use with MAA within 6 months to
a year. Manufacturers of bottles with smaller finishes (the part of a
bottle that receives the cap) may have to change to bottles with 20 mm
finishes. However, this should not present a problem since some of the
smallest sizes of bottles used for MAA-containing primers (0.25 ounces)
already have a 20 mm finish. Manufacturers of MAA-containing primers
concerned with spillage have the additional option of using a variety
of commercially available restrictive inserts to decrease the inside
diameter of the bottle opening in conjunction with CR 20 mm finishes.
One manufacturer of MAA-containing primers currently uses such a
restriction.
Special packaging for MAA-containing household products is
practicable. CT caps that meet the senior friendly and CR testing
requirements have been in mass production for many years. A 20 mm
continuous threaded closure that is CR and SF but lacks an insert for a
brush is now in mass production. Similarly, a 28 mm continuous threaded
closure that is CR and SF and does have an insert for a brush is in
mass production. The mass production and assembly line techniques used
for the 28 mm CR and SF closure with insert can be adapted to those
used for the 20 mm non-CR closure with an insert and brush.
Special packaging is appropriate when it will protect the integrity
of the substance and not interfere with intended storage or use. Nail
primers containing MAA are currently packaged in both glass and plastic
bottles. Thus, both glass and plastic containers are suitable for MAA-
containing products. One packaging manufacturer uses identical
materials to produce a 28 mm continuous threaded CR and SF closure
(equipped with an insert for attaching a brush) and a 20 mm continuous
threaded non-CR closure that is currently used for MAA-containing
primers and is equipped with an insert and attached brush. Plastic
bottle neck restriction devices should also be compatible with MAA
since at least one is already in use. Therefore, the same materials
used for non-CR packages of MAA-containing products, with or without
brushes or inserts, are used or can be used for CR-packages.
3. Other Considerations
In establishing a special packaging standard under the PPPA, the
Commission must consider the following:
a. The reasonableness of the standard;
b. Available scientific, medical, and engineering data concerning
special packaging and concerning childhood accidental ingestions,
illness, and injury caused by household substances;
c. The manufacturing practices of industries affected by the PPPA;
and
d. The nature and use of the household substance. 15 U.S.C.
1472(b).
The Commission has considered these factors with respect to the
various determinations made in this notice, and preliminarily finds no
reason to conclude that the rule is unreasonable or otherwise
inappropriate.
F. Exemption
The Commission is aware of one MAA-containing primer that is
packaged in a tube with a fiber applicator tip. The container looks
like a plastic marker pen. The fiber strand holds the MAA so that no
free liquid flows through the device. An overcap covers the applicator
tip. Several manufacturers market this type of device for applying nail
primer. Some of these primers contain MAA.
The Commission believes that MAA-containing primers packaged in
this type of device do not pose a risk of serious injury. For this type
of package not to pose a risk to children, the Commission believes that
two conditions must be met: (1) the absorbent material must hold the
MAA so that no free liquid is in the device, and (2) through reasonably
foreseeable use the MAA will be released only through the tip of the
device. Reasonably foreseeable use would include reasonably foreseeable
abuse by children. These conditions are grounded in an existing
exemption from FHSA labeling for porous-tip ink-marking devices. 16 CFR
1500.83(a)(9).
Although it might be possible to develop a lug finish CR closure to
overcap these devices, based on the design of these devices and
available injury information, the Commission
[[Page 71805]]
does not believe that a CR cap is necessary. The volume of MAA
available and accessible is extremely small (total amount of material
in the devices is reportedly less than 1/2 gram). The only possible
route of serious injury would be from direct contact of the felt tip
with the eye. The staff has not identified any incidents involving
these types of devices. Thus, the Commission proposes to exempt MAA
containing primers contained in these marker-like devices if they meet
the conditions discussed above.
G. Effective Date
The PPPA provides that no regulation shall take effect sooner than
180 days or later than one year from the date such final regulation is
issued, except that, for good cause, the Commission may establish an
earlier effective date if it determines an earlier date to be in the
public interest. 15 U.S.C. 1471n.
The Commission proposes a one year effective date. Currently, 20 mm
CT caps that are CR and senior friendly are available. However, these
caps are not available with a built-in applicator brush. Thus,
manufacturers will need to make some modifications to provide a CR cap
with a built-in applicator. Such closures should be available within
one year. This includes time for closure manufacturers to produce the
20 mm closures and for product manufacturers to change existing
assembly lines to accommodate these closures. Some manufacturers may
need to change the bottles currently in use to bottles with 20 mm
finishes. A year provides time to produce commercial quantities of the
20 mm CR and SF closures, adjust assembly lines to a different bottle
size, and conduct testing following the PPPA protocol.
Thus, the Commission proposes that a rule would take effect 12
months after publication of a final rule and would apply to products
that are packaged on or after the effective date.
H. Regulatory Flexibility Act Certification
When an agency undertakes a rulemaking proceeding, the Regulatory
Flexibility Act, 5 U.S.C. 601 et seq., generally requires the agency to
prepare proposed and final regulatory flexibility analyses describing
the impact of the rule on small businesses and other small entities.
Section 605 of the Act provides that an agency is not required to
prepare a regulatory flexibility analysis if the head of an agency
certifies that the rule will not have a significant economic impact on
a substantial number of small entities.
The Commission's Directorate for Economic Analysis prepared a
preliminary assessment of the impact of a rule to require special
packaging for household products containing more than 5 percent
methacrylic acid.
As noted above, the Commission is aware of 13 companies that market
nail primers containing MAA. Seven of these may be small businesses. As
discussed above, the technology exists to produce CR packaging suitable
for use with MAA-containing nail primers. Requiring special packaging
for these nail primers may affect many small suppliers. However, the
impact on any individual supplier is expected to be small. Generally,
incremental costs for CR packaging are low relative to the retail cost
of the product. Moreover, these incremental costs would likely be
passed on to users (professional nail technicians and consumers who
purchase these nail primers). Thus, based on current information, the
Commission certifies that the proposed rule is not likely to have a
substantial effect on a significant number of small businesses. The
Commission requests suppliers, particularly small businesses, to
provide information on the impact the proposed rule would have on them.
I. Environmental Considerations
Pursuant to the National Environmental Policy Act, and in
accordance with the Council on Environmental Quality regulations and
CPSC procedures for environmental review, the Commission has assessed
the possible environmental effects associated with the proposed PPPA
requirements for MAA-containing products.
The Commission's regulations state that rules requiring special
packaging for consumer products normally have little or no potential
for affecting the human environment. 16 CFR 1021.5(c)(3). Nothing in
this proposed rule alters that expectation. Therefore, because the rule
would have no adverse effect on the environment, neither an
environmental assessment nor an environmental impact statement is
required.
J. Executive Orders
According to Executive Order 12988 (February 5, 1996), agencies
must state in clear language the preemptive effect, if any, of new
regulations.
The PPPA provides that, generally, when a special packaging
standard issued under the PPPA is in effect, ``no State or political
subdivision thereof shall have any authority either to establish or
continue in effect, with respect to such household substance, any
standard for special packaging (and any exemption therefrom and
requirement related thereto) which is not identical to the [PPPA]
standard.'' 15 U.S.C. 1476(a). Upon application to the Commission, a
State or local standard may be excepted from this preemptive effect if
the State or local standard (1) provides a higher degree of protection
from the risk of injury or illness than the PPPA standard and (2) does
not unduly burden interstate commerce. In addition, the Federal
government, or a State or local government, may establish and continue
in effect a non-identical special packaging requirement that provides a
higher degree of protection than the PPPA requirement for a household
substance for the Federal, State or local government's own use. 15
U.S.C. 1476(b).
Thus, with the exceptions noted above, the proposed rule requiring
CR packaging for household products containing more than 5 percent MAA
would preempt non-identical state or local special packaging standards
for such MAA containing products.
In accordance with Executive Order 12612 (October 26, 1987), the
Commission certifies that the proposed rule does not have sufficient
implications for federalism to warrant a Federalism Assessment.
List of Subjects in 16 CFR Part 1700
Consumer protection, Cosmetics, Infants and children, Packaging and
containers, Poison prevention, Toxic substances.
For the reasons given above, the Commission proposes to amend 16
CFR part 1700 as follows:
PART 1700--[AMENDED]
1. The authority citation for part 1700 continues to read as
follows:
Authority: Pub. L. 91-601, secs. 1-9, 84 Stat. 1670-74, 15
U.S.C. 1471-76. Secs 1700.1 and 1700.14 also issued under Pub. L.
92-573, sec. 30(a), 88 Stat. 1231. 15 U.S.C. 2079(a).
2. Section 1700.14 is amended by republishing the introductory text
of paragraph (a) and adding new paragraph (a)(29) to read as follows:
Sec. 1700.14 Substances requiring special packaging.
(a) Substances. The Commission has determined that the degree or
nature of the hazard to children in the availability of the following
substances, by reason of their packaging, is such that special
packaging meeting the requirements of Sec. 1700.20(a) is required to
protect children from serious personal injury or
[[Page 71806]]
serious illness resulting from handling, using, or ingesting such
substances, and the special packaging herein required is technically
feasible, practicable, and appropriate for these substances:
* * * * *
(29) Methacrylic acid. Except as provided in the following
sentence, liquid household products containing more than 5 percent
methacrylic acid (weight-to-volume) in a single retail package shall be
packaged in accordance with the provisions of Sec. 1700.15(a),(b) and
(c). Methacrylic acid products applied by an absorbent material
contained inside a dispenser (such as a pen-like marker) are exempt
from this requirement provided that: the methacrylic acid is contained
by the absorbent material so that no free liquid is within the device;
and under any reasonably foreseeable conditions of use the methacrylic
acid will emerge only through the tip of the device.
* * * * *
Dated: December 21, 1998.
Sadye E. Dunn,
Secretary, Consumer Product Safety Commission.
List of Relevant Documents
1. Briefing memorandum from Susan Aitken, Ph.D., EH, to the
Commission, ``Proposed Special Packaging Standard for Household
Products Containing Methacrylic Acid,'' November 23, 1998.
2. Memorandum from Susan Aitken, Ph.D., EH, to Mary Ann Danello,
Ph.D., Associate Executive Director, EH, ``Toxicity of Methacrylic
Acid'' August 12, 1998.
3. Memorandum from Susan C. Aitken, Ph.D., EH, to Mary Ann Danello,
Ph.D., EH, ``Human Injuries from Nail Products Containing
Methacrylic Acid,'' August 12, 1998.
4. Memorandum from Marcia P. Robins, EC, to Susan Aitken, Ph.D., EH,
``Economic Considerations: Proposal to Require Child-Resistant
Packaging for Household Products Containing Methacrylic Acid,''
August 17, 1998.
5. Memorandum from Tewabe A. Asebe, EH, to Susan Aitken, Ph.D., EH,
``Technical Feasibility, Practicability, and Appropriateness
Determination for Proposed Rule to Require Special Packaging for
Methacrylic Acid-Containing Products,'' August 17, 1998.
6. Memorandum from Bhooshan Bharat, Ph.D., LS, and Bhavi K. Jain,
MS, LS, ``Report on the Testing of Nail Products for Titratable Acid
Reserve (``TAR''), Quantification of Methacrylic Acid, and pH,''
August 20, 1998.
[FR Doc. 98-34345 Filed 12-29-98; 8:45 am]
BILLING CODE 6355-01-P